• 電話微信:13956953738

故障分析/Failure Analysis

卡特C系列發動機故障代碼表

發布時間:2017-10-25

FlashCodeSPN(1)/FMICodeDiagnosticCodeorEventCodeDescriptionofCode13-174-03-174-03-FuelTemperatureopen/shortto+batt

燃油溫度傳感器或線路故障174-04-174-04-Fuel Temperature short to ground

燃油溫度傳感器或線路故障16-626-05-2417-05-Ether Injection Control Solenoid open/short to +batt  

乙醚噴射控制電磁閥或線路故626-06-2417-06-Ether Injection Control Solenoid short to ground

乙醚噴射控制電磁閥或線路故障21-678-03-41-03-8 Volt DC Supply short to +batt

8V直流電源故障678-04-41-04-8 Volt DC Supply short to ground

8V直流電源故障620-03-262-03-5 Volt Sensor DC Power Supply short to +batt   

5V直流電源故障1079-03-620-04-262-04-5 Volt Sensor DC Power Supply short to ground   

5V直流電源故障1079-04-24-100-03-100-03Engine Oil Pressure open/short to +batt   

機油壓力傳感器或線路故障100-04-100-04-Engine Oil Pressure short to ground   

機油壓力傳感器或線路故障100-10-100-10-Engine Oil Pressure abnormal rate of change   

機油壓力更新率不正常25-102-03-102-03-Boost Pressure Sensor short to +batt   

增壓壓力傳感器或線路故障102-04-102-04-Boost Pressure Sensor short to ground   

增壓壓力傳感器或線路故障102-10-102-10-Boost Pressure Sensor abnormal rate of change   

增壓壓力更新率不正常102-03-1785-03-Intake Manifold Pressure Sensor voltage above normal   

進氣壓力傳感器電壓高于正常值102-04-1785-04-Intake Manifold Pressure Sensor voltage below normal   

進氣壓力傳感器電壓低于正常值102-10-1785-10-Intake Manifold Pressure Sensor abnormal rate of change   

進氣壓力更新率不正常26-108-03-274-03-Atmospheric Pressure open/short to +batt   

大氣壓力傳感器或線路故障108-04-274-04-Atmospheric Pressure short to ground   

大氣壓力傳感器或線路故障27-110-03-110-03-Engine Coolant Temperature open/short to +batt   

冷卻液溫度傳感器或線路故障110-04-110-04-Engine Coolant Temperature short to ground   

冷卻液溫度傳感器或線路産28-91-13-91-13-Throttle Position calibration required   

油門需要校准32-91-08-91-08-Throttle Position signal abnormal   

油門信號不正常34-190-08-190-08-Engine Speed signal abnormal   

發動機轉速信號不正常723-08-342-08-Secondary Engine Speed signal abnormal   

备用發動機轉速信號不正常35-190-15-E362 (1)-Engine Overspeed Warning   

發動機超速報警190-00 -E362 (3)-Engine Overspeed Shutdown   

發動機超速停機37-94-03 -94-03-Fuel Pressure open/short to +batt   

燃油壓力傳感器或線路故障94-04-94-04-Fuel Pressure short to ground   

燃油壓力傳感器或線路故障38-105-03-172-03-Intake Manifold Air Temp open/short to +batt   

進氣溫度傳感器或線路故障105-04-172-04-Intake Manifold Air Temp short to ground   

進氣溫度傳感器或線路故障42-637-13-261-13-Engine Timing calibration required   

發動機正時需校准46-100-17-E360 (1)-Low Engine Oil Pressure Warning   

機油壓力低報警100-18- E360 (2) - Low Engine Oil Pressure Derate   

機油壓力低降載100-01-E360 (3)-Low Engine Oil Pressure Shutdown   

機油壓力低停機51-168-00-168-00 -System Voltage high   

系統電壓高168-01-168-01-System Voltage low   

系統電壓低168-02-168-02-System Voltage intermittent/erratic   

系統電壓不正常56-630-02-268-02-Check Programmable Parameters   

發動機參數設置需檢查58-639-09-247-09-J1939 Data Link communications   

J1939數據鏈接故障61-110-15-E361 (1)-High Engine Coolant Temperature Warning   

冷卻液溫度高報警110-16-E361 (2)-High Engine Coolant Temperature Derate   

冷卻液溫度高降載110-00-E361 (3)-High Engine Coolant Temperature Shutdown   

冷卻液溫度高停機62-111-17-E2143 (1)-Low Engine Coolant Level Warning   

冷卻液位低報警111-18-E2143 (2)-Low Engine Coolant Level Derate   

冷卻液位低降載111-01-E2143 (3)-Low Engine Coolant Level Shutdown   

冷卻液位低停機63-94-15 -E096 (1)-High Fuel Pressure Warning   

燃油壓力高報警64-1636-15-E539 (1)-High Inlet Air Temperature Warning   

進氣溫度高報警1636-00-E539 (3)-High Inlet Air Temperature Shutdown   

進氣溫度高停機65-174-15-E363 (1)-High Fuel Temperature Warning   

燃油溫度高報警174-16-E363 (2)-High Fuel Temperature Derate   

燃油溫度高降載174-00-E363 (3) High Fuel Temperature Shutdown   

燃油溫度高停機67-0441-15-E445 (1)-High Auxiliary Temperature Warning   

輔助溫度高報警0441-16-E445 (2)-High Auxiliary Temperature Derate   

輔助溫度高降載0441-00-E445 (3) -High Auxiliary Temperature Shutdown   

輔助溫度高停機0441-03-1836-03-Auxiliary Temperature Sensor open/short to +batt   

輔助溫度傳感器或線路故障0441-04-1836-04-Auxiliary Temperature Sensor short to ground   

輔助溫度傳感器或線路故障68-1387-15-E443 (1) -High Auxiliary Pressure Warning   

輔助壓力高報警1387-16 -E443 (2)-High Auxiliary Pressure Derate   

輔助壓力高降載1387-00-E443 (3) -High Auxiliary Pressure Shutdown   

輔助壓力高停機1387-03-1835-03 -Auxiliary Pressure Sensor open/short to +batt   

輔助壓力傳感器或線路故障1387-04-1835-04-Auxiliary Pressure Sensor short to ground   

輔助壓力傳感器或線路故障71-651-05-001-05-Cylinder #1 Injector open circuit   

1缸噴油器故障651-06-001-06-Cylinder #1 Injector short   

1缸噴油器故障72-652-05-002-05-Cylinder #2 Injector open circuit   

2缸噴油器故障652-06-002-06-Cylinder #2 Injector short   

2缸噴油器故障73-653-05-003-05-Cylinder #3 Injector open circuit   

3缸噴油器故障653-06-003-06-Cylinder #3 Injector short   

3缸噴油器故障74-654-05-004-05-Cylinder #4 Injector open circuit   

4缸噴油器故障654-06-004-06-Cylinder #4 Injector short   

4缸噴油器故障75-655-05-005-05-Cylinder #5 Injector open circuit   

5缸噴油器故障655-06-005-06-Cylinder #5 Injector short   

5缸噴油器故障76-656-05 -006-05-Cylinder #6 Injector open circuit   

6缸噴油器故障656-06- 006-06-Cylinder #6 Injector short

6缸噴油器故障
返回頂部

在線客服中心

0551-64536067

很高興爲您服務!

微信二維碼