• 電話微信:13956953738

故障分析/Failure Analysis

卡特彼勒C9挖掘機故障代碼

發布時間:2017-10-25

故障碼Component failure故障部件車輛1

112        Accelerator Pedal 1 Failure加速踏板1故障

113        Accelerator Pedal /Brake Plausibility加速踏板與制動踏板信號不可信

116        Main Clutch Signal Failure離合信號故障

117        Brake Signal Failure制動踏板故障

119        Terminal 15 Failure 15 端子故障

11C        Water in Fuel燃油濾清器儲水器

211        Vehicle Speed Sensor Failure車速傳感器故障

215        Cruise Control Buttons Irreversible巡航控制按扭不可逆故障

315        Cruise Control Buttons Reversible Failure巡航控制開關可逆故障車輛2(繼電器/執行器)

125        Main Relay 2 Failure主繼電器2失效

126        Battery Voltage Failure蓄電池電壓故障

127        Engine Brake decompression Valve failure發動機制動失效

128        Main Relay 1-Short Circuit To Battery主繼電器1與電池短路

129        Main Relay 3 Failure主繼電器3故障

12A        Thermostarter Relay 1(Heater)發動機制動(主繼電器4)故障

12B        Air Heater 1 Power Stage Failure空氣加熱器1 Power Stage 故障

12E        Pre-Post Heating Control System (Active)預加熱控制系統故障

225        Main Relay failure (Interrupted Afterrun)主繼電器失效(停機後中斷)

228        Main Relay 1 (High Pressure Pump) Short to Ground主繼電器1對地短路發動機1(溫度和壓力傳感器)

131        Coolant Temperature Sensor failure冷卻液溫度傳感器

132        Coolant Temperature Dynamic failure冷卻液溫度傳感器动态故障

133        Boost Air Temperature Sensor failure進氣溫度傳感器

134        Boost Pressure Sensor failure進氣壓力傳感器

135        Fuel Temperature Sensor failure燃油溫度傳感器

136        Rail Pressure Sensor failure共軌壓力傳感器

137        Common Rail Pressure Limiting Valve failure共軌壓力限壓閥

138        Oil Pressure Sensor failure機油壓力傳感器

13A        Oil Temperature Sensor failure機油溫度傳感器

232        Coolant Temperature Test failure冷卻液溫度(監測)

236        Rail Pressure Sensor Offset Monitoring共軌壓力傳感器偏差監測

238        Oil Pressure too low機油壓力過低

23A        Oil Temperature too high機油溫度過高發動機2(轉速傳感器/執行器)

141        Crankshaft Speed Signal failure曲轴轉速傳感器

142        Engine runs with Camshaft Speed only只有凸輪軸傳感器信號

143        Camshaft Speed Signal failure凸輪軸傳感器

144        Offset between Camshaft and Crankshaft凸輪軸傳感器和曲轴传感器信号偏差超出限值

149        Filter Heater failure燃油濾芯加熱器故障

14A        Engine Compartment Start Button stuck發動機機艙啓動按鈕發卡

14D        Info: Engine Overspeed Protection提示:發動機超速保護

24A        Engine Compartment Stop Button stuck發動機機艙停止按鈕發卡共軌系統燃油計量

152        Rail Pressure Positive Deviation High and High Fuel Flow Setpoint Value共軌壓力正偏差過高和燃油流量設定值過高

153        Rail Pressure Negative Deviation too High on Minimum Metering共軌壓力負偏差過高(最小流量)

154        Rail Pressure below Minimum Limit in Controlled Mode共軌壓力低于最小極限

155        Rail Pressure above Maximum Limit in Controlled Mode共軌壓力大于最大極限

156        Rail Pressure Drop Rate too High共軌燃油壓力下降率太高

157        Setpoint of Rail Metering Unit not plausible in Overrun超速時共軌計量閥不真實

158        Fuel Flow Setpoint of Common Rail Metering Unit too low共軌計量裝置燃油流量設置點過低

159        Common Rail Metering Unit Power Stage failure共軌油泵計量閥Power Stage 故障

259        Common Rail Metering Unit Power Stage Short to Battery共軌計量閥正極短路

359        Common Rail Metering Unit Power Stage Short to Ground共軌計量閥負極短路噴油器1

返回頂部

在線客服中心

0551-64536067

很高興爲您服務!

微信二維碼